物料安全資料表(MSDS)
1.物品名稱:彈性體脫模劑 MK -CE311
Product name: elastomeric release agent MK-CE311
2.成份辨識資料：
Component identification data:
成份名稱 Component name
|
,氟樹脂 Fluororesin 10%,特殊離型成份 Special demoulding components 32%，助劑auxiliaries 3%，硅油 Silicone oil 55%
|
3. 物理及化學性質：Physical and chemical properties
外觀 Appearance:無色透明液體 | Ph(5 % 稀釋液)：7 | 折光系數 @20℃ ： 1.2 |
Colorless transparent liquid | Ph (5% dilution): 7 | Refraction coefficient @20 C: 1.2 |
味道：無刺激性氣味 | 使用溫度：30 ℃-180 ℃ | 密度：0.98ph |
Odor : No strong smell | Operating temperature: 30℃ -180℃ | Density: 0.98ph |
4. 危害辨識資料：Hazard identification data:
危害與效應 Hazards and effects | 1. 對皮膚接觸 ：無毒性作用，經常及持續的皮膚接觸可能會造成皮 膚表面失去脂肪及干燥，而導致皮膚病變及皮膚發炎。 |
1. Sk in co ntact : Non- toxicity, oft en ａnd persi stent sk in co ntact may caus e the skin to lose fat an d dry ing , and lead to skin les ions an d inflam mati on. | |
2. 對眼睛接觸：造成眼睛不適，但不會傷害眼睛組織。 | |
2. Eye contact : cause eye discomfort, but will not damage the eye tissue. | |
3. 吸入：極少揮發，一般不會造成傷害。 | |
3. Inh alati on: little volatile, generally will no t cause harm . | |
4.食入：若不慎吞入或嘔吐物而造成少量物進入肺部時，會造成肺 氣腫或肺炎，非常低的毒性反應。 | |
4.Ing estion : if accidentally swallo wed or vomit caused a smal l amou nt of material into the lu ngs , can caus e emp hys ema or pneumo nia, toxicity is very low. |
5. 急救措施：Emergency treatment:
不同暴
露途徑之
急救方法
The first aid for different exposure routes
| 1.吸入：將受侵襲影響者，移開危險區域，并施以適當的處置，以保持通 暢的呼吸，若是患者不規律的呼吸，或者是停止呼吸時，立刻施以人 工呼吸法急救。盡量使患者休息并立刻實施藥物治療。 |
2.Inhalation: remove the affected effect away from the danger zone, and proper disposal, to maintain smooth breathing, if patients with irregular breathing, or has stopped breathing, artificial respiration immediately to the emergency. To enable patients to rest and drug treatment immediately. | |
2.皮膚接觸：手觸之處不會留下指膜 | |
3.Skin contact: hａnd touch points will not leave a membrane. | |
3.眼睛接觸：立刻以大量清水沖洗眼睛，直到刺痛感減輕為止(大約 10-15 分鐘)，若是刺痛感持續時，請立刻就醫。 | |
4.Eye contact: flush eyes with plenty of water immediately, until the tingling reduce far (about 10-15 minutes), if the pain persists, consult a doctor promptly. | |
4.食入：千萬不要引發患者嘔吐，使患者休息，并立刻請醫生來處理。 | |
5.Ingestion: don't cause vomiting and make the patient to rest, immediately asked the doctors to deal with. |
6. 滅火措施：Extinguishing measures:
適當的滅火材料：不易燃，可用污水處理設備進行微生物處理環保。
Suitable extinguishing material: non flammable, can use for sewage treatment equipment for microbial treatment and environmental protection.
注意事項：1、不要將水直接灑入容器內，以避免泡沫外泄(溢出) 。 2、為了保護人體及降溫，可用冷水噴灑危險區域，并避免將易燃物質聚集一處。
Note: 1, do not sprinkle water directly into the container, in order to avoid bubble leak (overflow). 2, in order to protect the body and cooling, cold water can spray the danger zone, and avoid
文件名稱 | 物料安全資料表(MSDS) | 制定日期 | 2017/03/01 | ||
文件編號 | ICTI039-26 | 版 本 | 1.3 | 頁 次 | 2/2 |
flammable material gathered.
7. 安全儲存事項：Safety storage note:
1. 保持容器開關口緊閉。
2. Keep cont ain er swit ch port clo sed .
3. 儲藏在陰涼干爽的地方，不用時保持容器密封，遠離高溫、火源。
4. Stored in a cool dry place, keep container tightly closed when not in use,keep away from heat, fire.
5. 避免直接暴露在陽光下暴曬，避免與強氧化劑、強堿、強酸接觸。
6. Avoid direct exposure in the sun, avoid contact with strong oxidizing agents, alkali, strong acid contact.
7. 將原料儲存于 4?48℃環境保存，存放時間不應超過 12 個月；保持容器封口密封。
8. Raw materials will be stored in the 4 ~ 48 ℃ environment preservation, storage time should not exceed 12 months; keep container seal.
8. 搬運時注意事項：Carry notes:
小 心輕放，裝卸時避免磕碰。運輸過程中要確保容器不泄漏、不倒塌、不墜落、 不損壞。
Handle with care, avo id clash when loading an d un loadin g. The trans port pro cess
to ensu re that the co ntainer does not leak, does not co llapse, did not fall, no damage.
9. 防泄漏處理 Anti leakage treatment
脫 水劑加入硬水中，會產生乳白色混濁，可用風槍吹去殘留水珠。
The dehyd rating ag en t ad ding hard water, will pro duce milk whit e haze, can blow to the resid ual water with air gun.
10.廢棄處理注意事項：Scrap disposal notes:
由有資格的回收商作回收處理。 Recovery processing by qualified recyclers.
11.穩定性和反應性 Stability and reactivity
禁忌物 | 無 | Taboo | non |
聚合物 | 無 | Polymer | non |
12.生態學資料 Ecological data
沒用生態毒性或生態信息需要報告 No toxicity or ecological information need report.
13.毒理學資料 Toxicological data
此產品無毒性 This product is non-toxic.
14.運輸信息 Transport information
在運輸過程中歸類為一般運輸品
In the transport process classified as common substances.
危險貨物編號 非易燃品 The number of dangerous goods： Nonflammable
UN 編號 | 沒有 UN NO. | non |
| |
包裝標志 | 沒用 | Packing mark | non | |
包裝 | 沒用 | Package | non |
|
運輸注意事項 無 Transport notes | non | |||
15.法規信息 Regulatory information
法規細節 Regulations details
其他法規 Other regulations
美國法規細節 (TSCA) 符合規定
中國法規細節 (IECS) 符合規定
American regulations details (TSCA) meet the specified
Details of Chinese regulations (IECS) meet the specified
16.其他要求 Other requirements
發行記錄 /
編制日期 /
修訂日期 /
Release record /
Compilation data /
Revision date /
